Suzuki Address V100 1998 ( CE11A - AG100T ) running problem

[cypriot]

Hı all,

My Suzuki Address V100 (2 stroke Air cooled) which I restored mostly its body etc was runnig fine till one day while I was  driving .

First it starts boğ shen apply throttle and thenengine stopped. I started it but diye again when apply even very litle.

I  thought that carburater clogged and need clening. I disassmble an clean carburater, pilot and main jet and sure that all passages are clean.

Then I install it and nothing change scooter can only start and die within several seconds or die as soon as apply throttle.

I thought that reed / reed pedals damaged or something prevent them to seal properly. I check reed and they are not faulty, seal properly.

I remove air filter and put my hand to feel if there is a vacum when try to start. There is vacum but some gas go filter side and not reed valve (inlet) side

I then think that carb not cleaned enough and install my spare carburater bit still same problem.

Ignition works, spark plug is new, just install it a month before problem occured.

Checked Exhaust and it is not clogged.

The only thing that I didnt checked yet crank seals.

I am not sure if worn / faulty crank seal cause no start or start and die when apply throttle.

Please help me to solve this issue.

Cypriot 

[jackrides]

Compression check? Ignition off, throttle wide open. Specify if the gauge has a valve (like an inner tube valve) at the end of the hose that screws into the spark plug hole.

[cypriot]

Feb 10, 2024 15:11:24 GMT -5 jackrides said:

Compression check? Ignition off, throttle wide open. Specify if the gauge has a valve (like an inner tube valve) at the end of the hose that screws into the spark plug hole.

Hello,

I will get compression check tool from my mechanicer friend snd measure compression.

As I diagnosis up to now it has enough compression btw.

I suspect there is an Air leak.

I noticed that it idles till auto enricher close extra gas (abouet 4-5 minutes) arter that it can not idle also.

I checked fuel delivery from tank to petcock, to Clear filter and üre to carburater and it is not clogged which means that enough fuel reach to the carburater.

As I wrote before carburater cleaned also spare öne tried but no change of problem

[jackrides]

Some carbs or fuel lines have a vacuum shutoff for when the engine is not running. Possible source of vacuum leak.

[Kagouras]

i cant help you but i want to ask
are you from cyprus?greek here
if yes you re the first greek speaking person in the forum except me

[cypriot]

Feb 13, 2024 7:23:40 GMT -5 Kagouras said:

i cant help you but i want to ask
are you from cyprus?greek here
if yes you re the first greek speaking person in the forum except me

Hello,

Yes İ am from Cyprus . I am Turkish speaking Cypriot.

Two Cypriot here

Cheers

[cypriot]

I found the problem when I have time to check scooter last Sunday

As I wrote my previous post I checked compression which was 100psi. İt is enough for start and rün this scooter.

Anyway I also checked spark of plug again and feel that it is weak and stop. I installed another ignition coil which solve problem